Skip to main content

Stiffer roads, less fuel?

Researchers at the Massachusetts Institute of Technology looked at how much fuel – and, hence carbon – could be saved by making roads in the US stiffer. They concluded that by resurfacing 10% of roads every year for the next 50 years, 0.5% of total transport emissions, or 440 megatons, would be saved over that period.
October 19, 2020 Read time: 3 mins
© Albertnowicki | Dreamstime.com

Extra fuel is burnt due to a number of pavement properties that impact on how the road surface and the vehicle interact. Friction is one of these – the higher the friction, the more fuel is burnt – and this is most relevant for cars.For trucks, deflection is more relevant; the weight of the vehicle causes the pavement to deflect and then fuel is required to push the vehicle up over the ‘bump’.

The MIT study, conducted by postdoctoral researcher Hessam Azarijafari, research scientist Jeremy Gregory, and principal research scientist in the Materials Research Laboratory Randolph Kirchain, concentrated on the deflection-induced effect.

Their argument is that while car traffic is likely to decrease, freight will increase. While this may not necessarily be true, it is likely that cars will be powered by renewable electricity at an earlier stage than trucks due to challenges around battery technology.

The researchers used data from 30 national databases to plug into their study and modelling. The climate of each state was also taken into consideration. In cold climates, such as Colorado, the roughness-induced excess fuel consumption is far more significant than deflection-based excess consumption – between six and 10 times more.

However, in warmer states deflection-induced consumption is three times that of friction-based consumption for asphalt pavements, although equal for concrete ones.

The study looked at ways of increasing pavement stiffness, or E modulus, such as adding fibres or carbon nanotubes or adjusting the mix design by changing the grading or type of aggregate and the properties of the binder. The analysis considered increasing the E modulus, by resurfacing at a rate of 10% of roads a year, to be equal to that of the 95th percentile of roads recorded in the Long-Term Pavement Performance (LTTP) database.

The researchers conclude that “the reduction in emissions from pavement use can be achieved with no changes in either 12 technology or manufacturing practices or the use of novel construction materials”. However, an increase in stiffness can have an adverse impact on other performance criteria such as cracking, something that is not considered in the report. There are many contributing and conflicting characteristics that impact on the whole life carbon impact of a road, not least the number of times it must be maintained.

Research and trials by the Danish Road Directorate which saw test sections paved from 2012, looked at reducing the frictional element of fuel wastage by changing the composition of the road surface to provide a low rolling resistance.

However, although the surfaces could deliver a fuel saving of around 6%, the test sections started ravelling within two years. Following more research, a new type of low rolling resistance asphalt is now under trial in Denmark, with a section laid in 2018.

For more information on companies in this article

Related Content

  • Benefits of bitumen technology research
    March 15, 2012
    Bitumen technology is benefiting from years of research and development - Kristina Smith. On a 2.7km loop of road in Auburn in Alabama, US, a lorry driver drives his triple-truck round and round. During his eight-hour shift, he will have covered 544km, with another driver waiting to take over from him for the next shift. Their mission is to seriously damage the road. This is the National Center for Asphalt Technology (NCAT), where sponsors from states and private companies pay to test out new materials and
  • Innovative advances in warm Mix Asphalts
    February 1, 2013
    Rising energy costs and increased awareness of safety and environmental issues have encouraged the development of Warm Mix Asphalts (WMA), which are typically produced at temperatures of between 130°C and 145°C, compared with around 175°C for traditional Hot Mix Asphalt (HMA). WMAs are regularly used in many European countries, as well as both North and South America. The three most common ways to lower the working temperature of asphalt are: a) foaming technologies; b) wax additives; and c) chemical (surfa
  • High-density polyethylene as a plastic additive
    November 18, 2021
    Using recycled plastic in a hot-mix asphalt requires choosing the right plastic with the appropriate mixing method, as Simon Tetley* in South Africa explains
  • Rapping with Anova in Phoenix
    February 5, 2021
    A recent test programme in Phoenix involving recycled asphalt pavement and the Anova asphalt rejuvenator from Cargill alerted the US city to environmental and cost savings that it was missing.