Tarmac tyre trial on UK motorway

Highways England is carrying out trials of rubberised asphalt on a busy stretch of UK motorway. A section of the M1 near the city of Leicester has been repaved by contractor Tarmac, using a special asphalt mix containing crumb rubber from recycled motor vehicle tyres. Tarmac has developed the mix specially to meet tough requirements from Highways England. This trial will determine how the stretch of highway, located between junction 22 and junction 23, behaves in terms of running wear, skid resistance and
August 7, 2019 Read time: 2 mins

8100 Highways England is carrying out trials of rubberised asphalt on a busy stretch of UK motorway. A section of the M1 near the city of Leicester has been repaved by contractor 2399 Tarmac, using a special asphalt mix containing crumb rubber from recycled motor vehicle tyres. Tarmac has developed the mix specially to meet tough requirements from Highways England.

This trial will determine how the stretch of highway, located between junction 22 and junction 23, behaves in terms of running wear, skid resistance and resistance to changes in temperature. The trial has been funded by Highways England to see whether crumb rubber from tyres can help provide a sustainable solution for road construction. Waste tyres from vehicles currently take up enormous space in landfill and provide a major concern with regard to fire safety and pollution. Being able to reuse the rubber from vehicle tyres in asphalt mixes would deliver an important solution for sustainable road construction and transport, as well as reducing waste disposal needs and the risk of fire or pollution.

Crumb rubber has been used extensively in asphalt mixes around the world, most notably in the Western US states of Arizona and New Mexico.

Around 40 million waste tyres from vehicles are produced/year in the UK and over 500,000 disused tyres are shipped out of the UK each year to be landfill. However, EU rules ban the disposal of tyres in landfill sites so these scrap tyres instead are transported to the Middle East and Asia. There are over seven million tyres filling a site in Kuwait.

Tarmac estimates that, depending on the thickness of the surface layers, up to 750 waste tyres/km of road could be used with the material.

Asphalt milling, paving & compaction

For more information on companies in this article

Related Content

  • Innovative surface treatment for concrete road
    July 30, 2019
    An innovative surface treatment approach by Foster Contracting Limited has been developed for use on a £745million roads project in Aberdeen, Scotland. The specialist contractor, Foster Contracting Limited (FCL), has played a key role in a major project, to build the Aberdeen Western Peripheral Route/Balmedie-Tipperty (AWPR/B-T). AWPR Construction Joint Venture, the contractor appointed to design and construct the project, approached FCL to provide a customised treatment to remove the latency from the sl
    Read More
  • Airport runway rebuild at Bologna
    May 15, 2019
    Rebuilding a runway requires special attention to detail to maximise efficiency and safety Airport runways face special challenges with regard to the loads they carry on a daily basis, particularly when aircraft are landing. A modern jet aircraft will typically land at speeds of around 240-260km/h, with a laden 747 weighing as much as 265tonnes at the end of a long flight. The stresses these large aircraft place on runway surfaces are enormous and not just with the massive impact forces exerted during
    Read More
  • Advanced technologies will increase the wear life of bitumen further
    February 28, 2012
    Bitumen has been used for thousands of years, but now a wide variety of products are available that can be added to it to produce blends with improved properties. According to the Refined Bitumen Association (RBA) bitumen is the oldest known engineering material. Indeed, the organisation says that its versatility as a construction material is unparalleled, and having been used as an adhesive, sealant and waterproofing agent for over 8,000 years, its uses include the construction and maintenance of roads, ai
    Read More
  • Epoxy for Ethiopia
    March 10, 2022
    Paving trials using epoxy resins in the Netherlands and New Zealand could lead to similar paving in Ethiopia, reports Kristina Smith.
    Read More

Highlighted Content