Skip to main content

Proven safety barrier installation practices

Barrier selection criteria should pay close attention to risks for stretches of road as well as regulations. Roadways need to have barriers to provide passive protection for users and to reduce the risk of injury or death in the event of a vehicle leaving the roadway. A wide array of regulations and legislation covers the design and installation of barriers on Europe’s roads. However, there are still a number of loopholes for certain types of roadside protection and further agreement is required to close th
June 27, 2013 Read time: 4 mins
Spanish regulations now require post protection systems on guard rails to reduce injury risks for motorcyclists

Barrier selection criteria should pay close attention to risks for stretches of road as well as regulations

Roadways need to have barriers to provide passive protection for users and to reduce the risk of injury or death in the event of a vehicle leaving the roadway. A wide array of regulations and legislation covers the design and installation of barriers on Europe’s roads. However, there are still a number of loopholes for certain types of roadside protection and further agreement is required to close these gaps. two-wheeler riders, for example, are not covered in some aspects of the existing regulations.

The UNE-EN 1317:2011 rule for road restraint systems uses key parameters to evaluate the effectiveness of a barrier system in mitigating the effects of leaving the roadway for four-wheeled vehicles. It includes the Acceleration Severity Index (ASI), which assesses the severity of the impact of a person against the barrier and the Theoretical Head Impact Velocity (THIV), which was designed to assess the severity of the occupants of these vehicles in these accidents. The impact severity index depends on the values of the ASI and the THIV. It is also possible to analyse damage to the vehicle following an impact

Trials were made on a pre-cast concrete protective and evaluated to the UNE-EN 1317 requirements. Tests for this type of protective system have now been made more demanding with the results of the tests showing crash severity A, with ASI values of less than 1, and THIV lower to 33km/h, which indicates a reduced risk of injury to occupants.

The UNE 135900 legislation covers the evaluation of protective barrier and parapet systems for motorcyclists. As motorcycles and mopeds account for about 10% of the vehicle fleet in Spain it is important that protection is extended to these users. Regulations are in place to evaluate the effectiveness of protection systems and include the Head Injury Criterion (HIC), through which it is possible to evaluate a head injury (CLE) that a motorcyclist may suffer. Forces and moments can be evaluated using accelerometers and load cells installed on the mannequin for the tests.

Following the assessment of the severity of impact tests performed and analysed according to the acceptance criteria of the UNE 135900 standard, the results showed crash severity level I, the minimum covered by the regulation. This showed a reduced risk of injury caused by the collision protection system. The trials also showed that there were no cuts or serious injuries inflicted on mannequins by this system.

To reduce risk of impacts occurring against obstacles located behind the step barrier, the protective system should have to redirect the path of any impacting vehicle. In addition, the protection should be fitted so as to minimise the risk of a vehicle rolling on impact with the edge of a gutter.

Ease of installation is a key factor and also helps minimise traffic delays, which themselves can increase risks from accidents due to vehicles bunching up at pinch points. Low maintenance and maximum durability are of importance, while the capability for fast replacement of damaged components following an impact is also a key feature. Metal components should be prepared so as to minimise corrosion, with techniques such as hot dip galvanising for steel to meet UNE-EN ISO 1461. This last is of particular importance in countries with poor winter conditions where salt is to prevent the formation of ice on the roadway. Meanwhile concrete structures should be resistant to frost or sulphate attack and meet the EHE-08 standard.

With vehicles leaving the roadway accounting for a significant percentage of traffic incidents, the design of roadway protection should meet requirements. A range of solutions are available and some low cost options are very effective according to tests.


*This is an edited version of a paper in Spanish by Aquilino Molinero Martínez, Alberto Mansilla Gallo, David Pedrero Muriel, and Giorgio Munaretto

Rider protection

Motorcyclist Protection Systems (MPS) can redirect a motorcyclist sliding on the road and are usually added to road safety barriers. As well as stopping the rider (and passenger) from hitting obstacles behind the safety fence, they also stop them hitting the rigid barrier support posts. The recent approval of CEN TS (TS 1317-8) allows companies to follow common assessment rules for MPS. One of the most effective designs is a two-part steel barrier with a normal guardrail at the top and a long and continuous protective sub-rail underneath. The sub-rail stops the rider sliding under the barrier and into roadside obstacles such as trees or lighting poles, as well as decelerating the motorcyclist. According to 3237 ArcelorMittal, its range of high strength steels (HSS) offer safe, protective systems for motorcyclists. These barriers are flexible enough to absorb the momentum of the rider and a motorcycle, yet robust enough to safely contain and redirect vehicles. When used with ArcelorMittal’s self-healing coating Magnelis, HSS barriers can offer long-term, cost-effective safety.

For more information on companies in this article

Related Content

  • Lightweight drain covers reduce risk of theft
    March 2, 2012
    With scrap metal prices soaring, some European countries are suffering from a spate of drain cover thefts. Serious safety issues arise for road users of all categories as a result of drain cover theft, with utility companies and local councils being left with the additional burden of replacing stolen ductile ironwork. However Ultracrete, part of the Instarmac Group, has a solution in the shape of its recently launched coverTEC range of pedestrian and road composite manhole covers and frames. These lightweig
  • England’s motorways not safe enough for 80mph limit, says RSF
    May 11, 2012
    England’s motorway network is not safe enough to have the speed limit raised to 80mph, according to a new report from the Road Safety Foundation (RSF). Titled ‘Unfit for 80’, the report says poorly-maintained and inadequate roadside protection and the rapidly rising risk of shunt crashes from the sheer volume of traffic using England’s motorways are key factors of safety concern. The RSF document has been published while the Government continues to consider a review of the motorway speed limit. Last autumn,
  • WJ Guardian system keeps stud installers safer in workzones
    January 26, 2017
    WJ’s latest innovation is a method of road stud installation designed to remove vulnerable operatives from the carriageway The bespoke design of the WJ Guardian system allows the complete road stud installation process to take place while protecting operatives within an integrated safety cell of an 18tonne truck. The UK has used 12 million road studs on its national and local road network, all requiring maintenance or replacement at some point. Traditional methods of installation by hand or milling ma
  • Driver distraction poses safety challenge
    June 5, 2015
    The modern automobile offers massive gains in safety over earlier generation vehicles. Occupant protection levels have been improved due to crash testing regimes that have ensured vehicles will not collapse catastrophically in the event of an impact. Braking systems are more effective and reliable, with ABS preventing skidding in wet weather conditions. The prospect of autonomous vehicles in the near future offer further safety gains to come. But right now, there is a problem. Too much technology is bein