Skip to main content

Overlay extends bridge's life

More than 3,000 vehicles a day pass over the US-95 Bridge over Lake Creek near the Coeur D'Alene Tribal Casino in Worley, Idaho, USA. The original deck, built in 2007, was poured concrete with a micro-silica layer added for protection. A QTT weather station with FreezeFree anti-icing technology is mounted in the bridge rail. With big variances in temperature and a lot of wind in this region, the original deck material became thick causing a near 80m length of micro-silica to over-harden. Idaho DOT engineers
July 24, 2012 Read time: 2 mins
More than 3,000 vehicles a day pass over the US-95 Bridge over Lake Creek near the Coeur D'Alene Tribal Casino in Worley, Idaho, USA.

The original deck, built in 2007, was poured concrete with a micro-silica layer added for protection. A QTT weather station with FreezeFree anti-icing technology is mounted in the bridge rail.

With big variances in temperature and a lot of wind in this region, the original deck material became thick causing a near 80m length of micro-silica to over-harden.

Idaho DOT engineers observed "dough balls" in the original placement, and these started to break off leaving voids in the bridge deck surface where water and ice have potential to collect.

Indeed, cracks occurred and Idaho Department of Transportation (IDOT) sought a solution to make the bridge deck watertight. Left untreated, the shrinkage cracks in the surface would more than likely have led to premature deck failure.

IDOT specified that contractor Max J. Kuney install a T48 Thin Polysulfide Epoxy Slurry Overlay manufactured by 350 Transpo Industries on the sections of the bridge deck due to the problems.

The polysulfide epoxy resin-based system resists the effects of ultra-violet degradation, while the slurry application method allows for installation with minimum traffic disruption.

Transpo says that the 9.5mm thick waterproof overlay adds minimal dead load to the structure, while the broadcast aggregate surface will maintain high skid resistance for many years.

Engineer for the project was HDR, and the surface was prepared with shot-blasting one lane at a time over for four lanes.

Transpo Industries also supplied the T-48 product Thin for the rehabilitation of the Interstate 70 overpass in Grainfield, Kansas, the first thin slurry type overlay used by the Kansas DOT.

It took the crew from contractor Wildcat Concrete Services just over 2 hours to complete each half of a 576m² bridge deck.

For more information on companies in this article

Related Content

  • Seal of approval
    August 2, 2012
    Timely maintenance using proven cost-effective methods can extend the life of a highway by many years as Patrick smith reports Highways are expensive assets to construct, and the wear and tear of modern traffic means that regular maintenance will delay costly repairs or in extreme cases reconstruction. There are a number of methods of carrying out such maintenance, and these include the use of slurry seals and micro-surfacing, which are cold mixed asphalt which is a mixture of graded aggregate, asphalt emul
  • U.S National Guard’s airport upgrade
    October 12, 2012
    In Kansas, specialist contractor Pavers has carried out important work for the National Guard. The aim of the work was to rehabilitate a WWII era hangar apron for the Kansas National Guard. The project required extensive repair work, including pavement patching, dowel bar retrofitting, partial depth patching and joint sealing. Pavers had to overhaul a 305m x 91.5m apron at Army Aviation Support Facility No 2 that suffered from poor drainage. The project included milling 152mm of old asphalt and concrete and
  • Utah pioneers 15cm thick-lift
    March 9, 2022
    Thick-lift paving could reduce road maintenance costs, as a recent trial in the US state of Utah is showing, reports Kristina Smith.
  • Well structured maintenance
    January 4, 2013
    Major bridge maintenance and replacement projects across the world are extending the life of many impressive historic landmarks as Guy Woodford reports The Tamar Bridge, part of the main A38 trunk road linking Saltash in Cornwall with Plymouth in Devon, south west England, marked its 50th anniversary with a steel deck resurfacing project involving Stirling Lloyd's Eliminator bridge deck waterproofing system. Jointly owned by Plymouth City Council and Cornwall Council, the Tamar has a suspended length of 642